“THE PLOVER” — 2018 MERCEDES-BENZ SPRINTER 2500 4×4 | OUTSIDE VAN CONVERSION
170″ Wheelbase – High Roof – Sleeps 2 – Seats 4 – Only 37,908 Miles
A no-expense-spared, fully off-grid 4×4 adventure van with just 37,908 miles, built by Outside Van (Troutdale, OR) — one of the most respected custom van builders in the country — on a 2018 Sprinter 170″ High Roof chassis, then finished with a complete overland suspension and armor package by Agile Offroad (Santee, CA). Over $233,000 invested in the build alone — roughly $202,000 in the Outside Van interior and systems and $31,000 in the Agile Offroad package — on top of the chassis. Full build invoices available. Graphite Grey, factory swivel cab seats, backup camera, 3.0L V6 turbodiesel.
This is not a production camper van. It is a one-off, invoice-documented expedition build with the electrical capacity, water capacity, heat, air conditioning, fuel range, and recovery equipment to live comfortably off-grid in any season — and the low mileage means it is just getting started.
CHASSIS & DRIVETRAIN
– 2018 Mercedes-Benz Sprinter 2500, 170″ wheelbase, High Roof
– Factory 4×4 / 4WD, 3.0L V6 turbodiesel
– Graphite Grey – factory swivel cab seats – backup camera
– Only 37,908 miles (approx. 4,700 miles/year, adult-owned, meticulously maintained)
POWER & ELECTRICAL (MASTERVOLT)
– 2x Mastervolt 12/5000 lithium-ion batteries — 720 Ah capacity (one of the largest battery banks ever put in a Sprinter of this era)
– Mastervolt Mass Combi 12/2500 inverter/charger
– 280XP second alternator with external regulator — recharges the bank fast while driving
– MPPT solar controller + EasyView 5 color control display
– 250W solar (2x 125W panels mounted on the safari rack)
– 110V outlets (x5), dual-USB outlets (x5), 12V high-amp ARB socket, shore power hookup
HEAT, A/C & WATER — TRUE FOUR-SEASON CAPABILITY
– Webasto Dual Top EVO 6 diesel hydronic system — 20,000 BTU cabin heat plus on-demand hot water, running off the van’s diesel tank
– 12V roof-top air conditioning — 13,000 BTU, runs while driving or on shore power, color-matched shroud
– 30-gallon fresh water tank, pump, carbon drinking-water filter, external fill
– Exterior hot/cold shower at the rear doors
– 2x Maxxair 10-speed reversible roof fans
GALLEY & LIVING
– 48″ custom galley cabinet with Webasto X-100 diesel cooktop (no propane on board)
– Isotherm 4.6 cu ft stainless refrigerator (Danfoss compressor)
– Elkay sink with Grohe Concetto faucet – PaperStone countertop (Gunmetal)
– Custom removable/stackable 3-panel bed system with King Casper memory-foam mattress and 37″ of garage clearance underneath for bikes, skis, and gear
– Mercedes 2-person bench seat plus front and captain’s seats re-upholstered in Graphite/Bronze leather with custom “Plover” embroidery
– Lagun swivel table system
– Custom potty box console (added new at purchase) — sized for a Thetford Porta Potti-style portable toilet (fits units 20″+ tall; just drop in a new ~$150 unit), with two storage drawers, integrated cup holders, wireless charging pad, and 110V/USB power outlets
– Solid-wood overhead cabinets, soft garage wall, overhead cab shelf
– Dimmable LED lighting throughout, load lights, full set of insulated sun shades
– 3M Thinsulate insulation + sound deadening, marine-grade plywood and vinyl floor
STORAGE & GEAR HAULING
– Mac VersaTie L-track throughout walls and ceiling, recessed in floor
– Fork mounts for bikes – Park Tool bike repair stand mounted on rear door
– Rear-door stuff sacks (upper and lower) – powder-coated gear hooks
OFF-ROAD & RECOVERY (AGILE OFFROAD — $31,000 PACKAGE)
– 4×4 suspension upgrade: front coil-assist, custom rear springs, Fox 2.0 shocks (front auxiliary + rear)
– Warn Zeon 12-S Platinum winch (12,000 lb) with synthetic line
– Full skid plate armor: engine, fuel tank, transmission/transfer case, DEF tank
– Nomad front bull bar bumper (winch mount, 2″ receiver) + Aluminess rear bumper with hitch, swing-arm and spare tire carrier
– Front and rear bumpers Line-X coated
– Black Rhino Overland 17×8 wheels on Toyo Open Country R/T 285/70R17 tires
– StopTech slotted rotors + performance brake pads
– Auxiliary 28-gallon rear fuel tank with transfer pump — roughly 50+ gallons total diesel for serious range between fill-ups
– ExtremeAire Magnum onboard air compressor with 2-gallon tank — air down and air back up anywhere
– Rigid/E-Series LED lighting: 50″ curved light bar, additional light bars, flood/spot kits, rear roof scene lights
EXTERIOR & CONVENIENCE
– Custom Safari aluminum roof rack (full 170″ length) with removable cross bars
– Fiamma 13’2″ awning
– Dual side ladder rack
– Electric retractable running boards (slider, passenger and driver doors)
– Xpel clear paint protection film (hood, A-pillars, grille, front quarters)
– 4G WeBoost cell signal booster
– Alpine audio: 8″ HD navigation head unit, 5-channel amp, JL Audio 10″ subwoofer
– Security alarm, Nest CO/smoke detector, fire extinguisher
WHY THIS VAN
Comparable Outside Van builds are selling factory-certified at $189,000 — without the Agile Offroad suspension, armor, winch, auxiliary fuel, and onboard air this van carries, and typically with more miles. A new build to this spec would run well over $300,000 with the current chassis and a multi-year waitlist. This van is ready now: broken in, sorted, and barely used.
Every core system was professionally designed and installed by Outside Van and Agile Offroad. Complete build documentation and invoices convey with the sale.
Clean title. Serious inquiries welcome — happy to walk through any system on a call or video.
